“We win!” exclaimed the young volunteer, raising his fists in the air in triumph. He had just heaved a nasty, mud-covered truck tire into our canoe as he stood knee-deep in the Miami River. His genuine enthusiasm was infectious, even though I am not a competitive or sports-following person. Yes, if we remove noxious debris from the habitat, I guess Mother Nature’s Team does win!
I’ve never forgotten this episode over the years, because I’ve witnessed the same fervor among our volunteers whenever we extract a tire from the coastline during our cleanups. Heck, I have felt that way myself when I loaded a real stinker into my solo canoe after pulling it out of the mangroves! It’s the challenge, I guess: large, bulky, slippery, full of water and muddy filth, hard to load into a canoe; a tire is the definitive example of civilization’s intrusion into the fragile habitat. You can see from the montage above we’ve removed quite a few of these bad boys from South Florida’s waterways.
This got me thinking, and then researching, about the ubiquitous tire.
The good news is that 90% of tires in the US are now recycled. But don’t get too excited; since there’s a tire scrapped each year for every person in the US, that’s still 10% of 311,000,000 tires that may end up where they are not wanted: like in our local waterways.
But people are finding ingenious ways to make use of an item once considered to be out-of-mind once it was out-of-sight. Back in “the good old days” people simply piled old tires out in the country, or in empty lots. Now there is less open space for such eyesores and ignorance, but even worse, tires collect rainwater and become breeding heaven for mosquitoes, while burning tire-piles are hell on earth.
In order of preference, the Environmental Protection Agency upholds this sequence: reduce, reuse, recycle, waste-to-energy, with appropriate disposal at the end of the list. Estimates vary, from one to three billion scrap tires currently stockpiled just in the U.S., so everyone needs to become part of the solution.
Reduce
How? Help your tires last longer. Simply keep them properly inflated, rotate and balance them every 4,000 miles, keep your vehicle in alignment. Choose to use your car as little as possible. You will save money while helping the environment.
Reuse
It’s heartening that people seem determined to reuse scrap tires, whole or in pieces, in a myriad of products. Tires rammed full of dirt are used to build houses, called “Earthships” for living off the grid. Roofing shingles are made from large pieces of tires, with the steel belts adding strength. As an artist myself, I was thrilled to find sculptures by Korean artist Yong Ho Ji: large and dynamic fantasy animals built from strips of tires that make especially fine use of tread patterns. Other artisans have crafted the tough rubber of tires into utilitarian items such as shoe soles, furniture, baskets, flowerpots, woven and crocheted floor mats, belts, gaskets, dock bumpers, planters, bike racks, playground equipment, toys, purses, wallets, even jewelry…and let’s not forget that much loved tire swing over the creek! One of my best childhood memories is when my dad gave me a huge inner tube from one of his airplane tires.
If there were an award for “Seemed Like a Good Idea at the Time But Instead Was an Ecological Disaster” my vote would go to the well-meaning coalition of folks who in 1974 dumped about two million tires into the ocean 7,000 feet off the coast of Fort Lauderdale. They were sure that this giant rubber jumble, dropped upon an artificial reef of concrete jacks known as Osborne Reef, would become a thriving habitat for fish, coral, and other undersea life. Some tires were tied together with steel or nylon bands, some just freely dumped by boaters. In hindsight, it seems incredible that nobody (on record) predicted that the bands would fail, and the tires would move, damaging natural reefs and organisms that had attached to the tires. Tropical storms and hurricanes shifted the tires for long distances. Despite the drastic failure of Osborne Reef, other countries attempted to install tire-reefs in the 1980s. In 2002, Ocean Conservancy’s director of strategic conservation, Jack Sobel, said, “I don’t know of any cases where there’s been a success with tire reefs.” Heroic attempts have been made to remove them but that’s too much for this brief article! Google “Osborne Reef” to learn more.
Recycle
After processing, the rubber from scrap tires becomes a component in at least 100 products. The metal from the steel belts must be removed and reclaimed. Then the tires are processed into shreds, crumbs, or powder on their way to becoming Tire Derived Product (TDP). Ground-up rubber is called crumb. The rubber not only meets the road, but becomes the road, as yearly, twelve million scrap tires go into rubberized asphalt to resurface highways. That’s the largest single use of recycled rubber. There’s a new recipe for railroad ties: grind up 80 pounds of scrap tires, add plastic from recycled bottles, wrap around a steel beam, and wait ninety years for it to wear out. That’s three times longer than a wooden tie and twice as strong. TDP makes rubber composite decks last 25 years with less maintenance than wood. Hyperseal Inc., a California company founded by chemical engineer and USAF Colonel (Ret.) Ronald Savin, uses TDP in their durable and waterproof coating products and caulks (I have to admit I am really excited to discover this company, as it sounds like their paint would be perfect for the deck of WRT’s eight-canoe trailer!). Apokalyps Labotek is a Swedish company that uses TDP for beautiful and tough parquet flooring. Chopped into larger, one-eighth-inch pieces, scrap tires become mulch that lasts far longer than wood mulch, won’t float away, or attract bugs or mold. It’s also used in playgrounds as a kinder, cushier surface than dirt.
Fun Fact: Next time you are in the market to rent a car, consider that Hertz has vowed to recycle every tire from its rental fleet, which in 2012 amounted to 170,000 tires.
Waste-to-Energy
The EPA or any other governmental agency (or anyone with common sense!) does not condone the disposal of tires by burning in the open. Tires burn fiercely, as each produces the same amount of energy as seven gallons of oil, and yield 25% more BTUs than coal, releasing thick black smoke and poisonous gasses into the air. Millions of tires are legally combusted as waste-to-energy in several industries. When shredded, they become tire derived fuel (TDF). However, there is controversy about the emissions that is beyond the scope of this article.
Disposal
Certainly, YOU, Dear Reader, are not the type of loathsome cad who would dispose of old tires by chucking them into the bushes or a waterway! Your state, city or county government can advise you on their tire disposal policies. To get rid of old tires, you may have to pay a fee, which may go to fund recycling or cleanup programs. The information you need will be easy to find on the internet.
Have I tired you out with the results of my research? Hope not; I, for one, feel better knowing that so many inventive and determined people are dealing with this obnoxious, omnipresent representative of our love affair with the automobile.
Meanwhile, Wildlife Research Team will continue to remove the tiresome relics of humanity from our precious habitat, thanks to the winning enthusiasm of our wonderful volunteers.
Hope to see you in a black canoe,
Wildlife Research Team's Blog 